Polestar Forum banner
21 - 40 of 250 Posts
Discussion starter · #22 ·
Getting the 3.6v out is a real PIA - carpet and trim pulled out but not understanding how the clip for the battery works
It's incredibly frustrating.

There are two tabs, on the side of the connector, one within the connector (to disengage that) and one behind it that clips the battery to the chassis. I find it's easier to pop up the battery and then disconnect it.

I'm not sure if anyone has a better photo of the connector somewhere, but if you could take one after you managed to disconnect it that'd be helpful to others!

This is a good idea to make it easier next time:

 
Discussion starter · #25 ·
Haha ya - clearly not designed to be easily removed, hopefully holds it firmly in place!
In your preferred method, how do I pop up the battery? Fingers/hands the right tools or ?
See this photo, it's taken from the side after I removed it, that's the tab in the left that's holding, it just behind the connector:

Image


So to use your photo, just use a small flat head screwdriver or similar object, insert it where the red line is and push the tab to the side and it'll pop out.

Image
 
Discussion starter · #26 ·
this is where I currently am at - sitting in the trunk of the car not sure of what to press/pull/wiggle.
Red line is where the tab for the connector is, if you just want to disconnect it use that, yellow line is where the tab for the battery is, use that to take it off and then disconnect it and place it somewhere less annoying like the other poster suggested, hope that helps!

Image
 
Super appreciate the quick replies.
Just to double check,

for the yellow line I would be pushing that tab towards the cables?
And the red -> not sure how to get something in there the way it is mounted, but if I could find a very very small flathead: insert right at the red mark & push to the left of the photo?
 
Discussion starter · #28 ·
Super appreciate the quick replies.
Just to double check,

for the yellow line I would be pushing that tab towards the cables?
And the red -> not sure how to get something in there the way it is mounted, but if I could find a very very small flathead: insert right at the red mark & push to the left of the photo?
Yeah, it's very hard to do the connector tab as it's placed, I generally don't bother, which is why I suggested you remove it, then it'll be much easier to pull the connector's tab (but not SO easy, the cable is short)

Here it is from the side again, insert a flat screwdriver or similar (yellow line) and apply some torque (green) so the tab moves.

So pull towards the back, the tab will move towards the front and it'll pop down on that side, then just rotate a bit and pull out the other side.

Worst that can happen is you break some of the plastic tabs, but if I were you I wouldn't be clipping it back again anyway!

Image
 
Had to do mine yesterday - keys not recognised and charger plug stuck in. I removed the piece of trim on the C -pillar (where the airbag logo is) as it makes it easier. Then pull back the carpet and push something through the oval hole in the body to release the battery which then drops down. The cable it is on is super short, so I pulled the cable retainer (with the zip tie) that holds the cable to the body out of the body hole (slightly breaking that clip, but meh). That gives you a lot more cable to pull the battery out clear of the carpet and into the trunk/boot.

Once you look at how the plug works, its simple enough to remove, just quite stiff.

Anyway, TCAM battery pull + 12V disconnect fixed the issues. It is rubbish that we have to do this though...!
 
Would it make sense to install a switch between the TCAM battery and module? If this issue is as persistent as it seems to be, it would save a lot of time in the future....would need to know the connector types though in order to build one.
The fact that this works as well as it does, you'd think PS would create a soft switch in one of the menus that severs and then reconnects the power. Clearly the current TCAM reset is not valuable.
 
Discussion starter · #32 ·
The fact that this works as well as it does, you'd think PS would create a soft switch in one of the menus that severs and then reconnects the power. Clearly the current TCAM reset is not valuable.
It looks like merely rebooting it (which is what the reset does) isn't sufficient, it needs to be power cycled, or in fact it might not be an issue with the TCAM but something else powered from it.

Either way I think it's unlikely that would be possible without additional hardware, so we're stuck pulling the fuses and disconnecting the backup battery.
 
Discussion starter · #33 ·
Would it make sense to install a switch between the TCAM battery and module? If this issue is as persistent as it seems to be, it would save a lot of time in the future....would need to know the connector types though in order to build one.
Mine's a lease so can't really do it, unless I can find compatible connectors. I think this is a great idea:


I'm sure I'll wish I'd thought of that next time I have to do it, and I'll certainly be doing it.
 
Red line is where the tab for the connector is, if you just want to disconnect it use that, yellow line is where the tab for the battery is, use that to take it off and then disconnect it and place it somewhere less annoying like the other poster suggested, hope that helps!

View attachment 15355
Unhooking the battery was the most difficult step for me the first time I did it. I've replaced engine mounts that were less infuriating.

Use your mini screwdriver to unlatch it. Just press it lengthwise up against the metal, flat blade towards the battery, handle towards the rear bumper. Then press it forward above the wire harness connector to the battery to kkonstan's handy yellow marking and it will press in the lock tab and you pull the battery down. You can do this just by feel (just don't drop the screwdriver) and then you can pull the battery out and use the screwdriver to unhook the harness at kkonstan's red mark then re-attach then hook the battery back up and snap it in.
 
It builds a character though … 😂 … I had some crazy thoughts the other day, to do a practise run, but I aborted the idea as being crazy. Murphy would step in and from that point it would be happening all the time, surely with my luck … I will wait until it happens, regardless when or where it happens. I warned my wife, that I might have to take apart back and front of the car while on a trip … she just laughed and said whatever.
 
Discussion starter · #37 ·
The Volvo Assistance engineer did it in seconds, I saw him pull the carpet trim, his hand went in with a screw driver and emerged with said screwdriver and a battery.

The first time I tried to do it it was incredibly frustrating for me - that Volvo Assistance engineer clearly had a lot of practice, so he made it look easy.

Anyway, much easier the 2nd time, and over in ~5 minutes. I sincerely hope you don't get to practice much though!
 
The Volvo Assistance engineer did it in seconds, I saw him pull the carpet trim, his hand went in with a screw driver and emerged with said screwdriver and a battery.

The first time I tried to do it it was incredibly frustrating for me - that Volvo Assistance engineer clearly had a lot of practice, so he made it look easy.

Anyway, much easier the 2nd time, and over in ~5 minutes. I sincerely hope you don't get to practice much though!
Yes, the second time is much much easier. The first time I considered sticking the screwdriver into the 400V battery pack and then I'd never worry about TCAMs again, or anything else for that matter.
 
I wonder, whether we could have a contest up here, for the TCAM reset participants ... at least to make a fun out of a nuisance .... 😂 .... post your attempt # and a time (video is a bonus). Not sure, what would be the appropriate winner prize though?
 
Discussion starter · #40 ·
I wonder, whether we could have a contest up here, for the TCAM reset participants ... at least to make a fun out of a nuisance .... 😂 .... post your attempt # and a time (video is a bonus). Not sure, what would be the appropriate winner prize though?
Definitely need to organise a contest at an owner's meetup - first one to remove the battery wins. Bonus points for not getting their hands full of scratches.
 
21 - 40 of 250 Posts